If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#21
|
|||
|
|||
Whats the deal with counter-rotating props?
IIRC the SE service ceiling of a Twin Comanche is about 3800MSL
You don't recally correctly, it's 5800. It goes down to 3800 if you get the Robertson STOL kit - but that's because of the 200 lb gross weight increase. The second engine, on failure of the first engine, will only lead you to a landing location, not necessarily of your choosing. My experience differs. When the left (critical) engine of my Twin Comanche failed (due to undetectable corrosion in the fuel servo) the remaining engine took me to a normal landing at an airport. Had I been in a single engine plane in the same situation, well, let's just say I was over Arkansas and there was an avtive airmet for mountain obscuration. Michael |
#22
|
|||
|
|||
Whats the deal with counter-rotating props?
Mike Noel wrote: if you slow it down too much with the engines still developing thrust, it can flip over on its back. So you can't practice power on stalls? How about landing, on final approach? Sounds pretty dicey. This is with both engines running? |
#23
|
|||
|
|||
Whats the deal with counter-rotating props?
We're looking into a twin and the Twin Comanche is on our list. I know
that the later models have the counter rotating props -- although i don't know too much about what this means, other than its "better". You've gotten a lot of uninformed opinions here. I started countering them, and after the first post decided it would be better to put it all in one place. I have over 900 hours in Twin Comanches of various flavors (including the CR), I've instructed in them, and I've worked on them. Having said that, here's what you're dealing with. There are exactly two things a counter-rotating prop does for you in flight. First, it relieves you of the necessity of applying right rudder on takeoff or climb. Second, it allows you to fly at a slightly lower airspeed in the event the left engine fails without rolling over - which boils down to being able to fly not just much too slow, but much, much too slow. The reality of the situation is that the PA-30 should never be flying at less than 90 mph unless (a) the runway is made and you are decelerating in preparation for the flare, in which case power is near-idle and an engine failure is irrelevant, (b) you are in ground effect accelerating after takeoff, in which case an engine failure calls for an immediate idling of the throttles and a touchdown straight ahead, or (c) you are at a safe altitude doing training. The downside is you get an engine where the prop, prop governor, magnetos, alternator, vacuum pump, fuel pump, oil pump, and tach adapter are nonstandard, and thus rarely stocked. On top of that, some of those parts are used only on that one engine (the counter-rotating IO-320) which is used on only that one airplane (the PA-30CR or PA-39) which hasn't been made in decades and of which relatively few were made. The impact on maintenance is spectacular. The reason Piper modified the original PA-30 (in many ways - they added control linkages, stall strips, and finally the counter-rotating props) was to make it a more docile trainer. They didn't succeed. If you buy the plane, make sure you find an experienced Twin Comanche instructor to train you. No amount of time in Seminoles, Duchesses, Apaches, Geronimos, or similar trainers prepares someone to fly a PA-30. I've seen what happens when someone who just took an MEI ride in a Duchess gets into a PA-30 - he can't hold on to the tail. You rarely see PA-30's as trainers anymore, and for good reason. When MEI's with 50-100 hours multi time tried to teach in them, the carnage was spectacular. You do not need an STC to convert a straight PA-30 to CR. There is a service bulletin from Piper for the conversion. All you need to do is buy the parts and convert the engine by simple parts replacement. That won't be cheap either. With the low altitudes and cool weather of the East coast, the service ceiling of the PA-30 is quite high enought (5800ft density altitude at gross). Contrary to popular opinion, the PA-30 will fly just fine on one engine, even at gross. BTDT. Most of the PA-30's out there now have been modified to reduce Vmc. The popular mod is the rudder fin (Knots-2-U and Robertson make them) which improves lateral stability and reduces Vmc. The real Vmc of a PA-30 without CR props is 80 mph. That's what was designed in and verified by flight test at Swearingen. However, that assumes you do everything right. Relatively small errors in technique can raise that. This was fixed by raising the Vmc marking on the ASI and in the AFM to 90 mph by AD (no changes were made to the airframe). If you want more info, just ask Michael |
#24
|
|||
|
|||
Whats the deal with counter-rotating props?
IIRC the SE service ceiling of a Twin Comanche is about 3800MSL
You don't recally correctly, it's 5800. It goes down to 3800 if you get the Robertson STOL kit - but that's because of the 200 lb gross weight increase. The aircraft I recently looked at did have the STOL kit.. thanx The second engine, on failure of the first engine, will only lead you to a landing location, not necessarily of your choosing. My experience differs. When the left (critical) engine of my Twin Comanche failed (due to undetectable corrosion in the fuel servo) the remaining engine took me to a normal landing at an airport. Had I been in a single engine plane in the same situation, well, let's just say I was over Arkansas and there was an avtive airmet for mountain obscuration. Michael Out here, most airports are around 3000MSL, with terrain over 8000MSL between them, add in the density altitude factor on a standard 100F or higher day.. and that single engine is not going to be me to an airport. BT |
#25
|
|||
|
|||
Whats the deal with counter-rotating props?
On Sat, 28 Jan 2006 20:22:23 -0800, Ron Wanttaja
wrote: On Sun, 29 Jan 2006 04:17:23 GMT, "Michael Ware" wrote: "Dico" wrote in message oups.com... We're looking into a twin and the Twin Comanche is on our list. I know that the later models have the counter rotating props -- although i don't know too much about what this means, other than its "better". Thanks, Think about what you do with your right foot during takeoff. Most trigear pilots are scratching themselves behind the right ear. :-) Not the ones behind big engines. :-)) Roger Halstead (K8RI & ARRL life member) (N833R, S# CD-2 Worlds oldest Debonair) www.rogerhalstead.com Ron Wanttaja |
#26
|
|||
|
|||
Whats the deal with counter-rotating props?
Michael,
You only left out one part: when a pilot does learn to fly the PA30 and stay ahead of it, it's a blast to fly!! (especially the turbo'd model) -----Original Message----- From: Michael ] Posted At: Monday, January 30, 2006 11:54 AM Posted To: rec.aviation.owning Conversation: Whats the deal with counter-rotating props? Subject: Whats the deal with counter-rotating props? We're looking into a twin and the Twin Comanche is on our list. I know that the later models have the counter rotating props -- although i don't know too much about what this means, other than its "better". You've gotten a lot of uninformed opinions here. I started countering them, and after the first post decided it would be better to put it all in one place. I have over 900 hours in Twin Comanches of various flavors (including the CR), I've instructed in them, and I've worked on them. Having said that, here's what you're dealing with. There are exactly two things a counter-rotating prop does for you in flight. First, it relieves you of the necessity of applying right rudder on takeoff or climb. Second, it allows you to fly at a slightly lower airspeed in the event the left engine fails without rolling over - which boils down to being able to fly not just much too slow, but much, much too slow. The reality of the situation is that the PA-30 should never be flying at less than 90 mph unless (a) the runway is made and you are decelerating in preparation for the flare, in which case power is near-idle and an engine failure is irrelevant, (b) you are in ground effect accelerating after takeoff, in which case an engine failure calls for an immediate idling of the throttles and a touchdown straight ahead, or (c) you are at a safe altitude doing training. The downside is you get an engine where the prop, prop governor, magnetos, alternator, vacuum pump, fuel pump, oil pump, and tach adapter are nonstandard, and thus rarely stocked. On top of that, some of those parts are used only on that one engine (the counter-rotating IO-320) which is used on only that one airplane (the PA-30CR or PA-39) which hasn't been made in decades and of which relatively few were made. The impact on maintenance is spectacular. The reason Piper modified the original PA-30 (in many ways - they added control linkages, stall strips, and finally the counter-rotating props) was to make it a more docile trainer. They didn't succeed. If you buy the plane, make sure you find an experienced Twin Comanche instructor to train you. No amount of time in Seminoles, Duchesses, Apaches, Geronimos, or similar trainers prepares someone to fly a PA-30. I've seen what happens when someone who just took an MEI ride in a Duchess gets into a PA-30 - he can't hold on to the tail. You rarely see PA-30's as trainers anymore, and for good reason. When MEI's with 50-100 hours multi time tried to teach in them, the carnage was spectacular. You do not need an STC to convert a straight PA-30 to CR. There is a service bulletin from Piper for the conversion. All you need to do is buy the parts and convert the engine by simple parts replacement. That won't be cheap either. With the low altitudes and cool weather of the East coast, the service ceiling of the PA-30 is quite high enought (5800ft density altitude at gross). Contrary to popular opinion, the PA-30 will fly just fine on one engine, even at gross. BTDT. Most of the PA-30's out there now have been modified to reduce Vmc. The popular mod is the rudder fin (Knots-2-U and Robertson make them) which improves lateral stability and reduces Vmc. The real Vmc of a PA-30 without CR props is 80 mph. That's what was designed in and verified by flight test at Swearingen. However, that assumes you do everything right. Relatively small errors in technique can raise that. This was fixed by raising the Vmc marking on the ASI and in the AFM to 90 mph by AD (no changes were made to the airframe). If you want more info, just ask Michael |
#27
|
|||
|
|||
Whats the deal with counter-rotating props?
This if from the August 2004 issue of AOPA Pilot:
'NASA's July 1971 final report reached three conclusions about the PA-30 Twin Comanche: * At the stall, large rolling and yawing moments occurred as a result of asymmetric wing stall. The left wing stalled, NASA said, at an angle of attack about 2 degrees lower than the right wing. * These rolling and yawing moments are larger than the corrective moments produced by aileron and rudder controls. * The airplane exhibits a flat spin under certain conditions involving the use of asymmetric power.' I interpret the first two items to apply to a Comanche with both engines operative, with only the last referring to a single engine Vmc situation. -- Mike Noel, Tucson, Arizona 'Men never do evil so completely and cheerfully as when they do it from religious conviction.' -Blaise Pascal "Mike Noel" wrote in message . .. I didn't notice anyone bring this up in the thread. The AOPA published some interesting stuff on the Twin Commanche without CR props since they were giving one away last year. With the older style twin, if you slow it down too much with the engines still developing thrust, it can flip over on its back. One of the wings is effectively flying at a couple of degrees higher angle of attach due to the prop airflow. I think this is the main reason the newer Twin Comanches went to CR props. -- Mike Noel, Tucson, Arizona 'Men never do evil so completely and cheerfully as when they do it from religious conviction.' -Blaise Pascal "Dico" wrote in message oups.com... Hello, We're looking into a twin and the Twin Comanche is on our list. I know that the later models have the counter rotating props -- although i don't know too much about what this means, other than its "better". We fly a mooney now and thus I don't worry about the prop -- as long as it keeps spinning. Is there a web site that gives a good explanation as to why I want CR props. There are hundreds of the earlier model Twin Comanches flying without the CR props --- so what does someone with 300 hours single engine time need to worry about? What actually goes wrong? And when it does, what happens? I hear "critical engine" but it means very little to me. I like to fly and try to be very careful when I do fly... but I don't follow too much aviation stuff other than how it affects me -- so I'm not exactly a "buff", hence the above questions which may seem obvious to many. Why are we looking at a Twin Comanche? Because its a twin, safer for IFR flight (perhaps this is only preceived), plus we live on the east coast on an island so we're flying over water quite a bit. Also this plane has decent speed and is an "economical" twin. We rarely fly with 4 people, so we don't need any more seats than 4. Any help or links to help would be appreciated. Thanks, Dico |
#28
|
|||
|
|||
Whats the deal with counter-rotating props?
You only left out one part: when a pilot does learn to fly the
PA30 and stay ahead of it, it's a blast to fly!! (especially the turbo'd model) You're right - I left that out. I figured that part was obvious Seriously - the plane had some rough edges, but nothing touches it for comfort and efficiency in twins, and it is a blast to fly once you get out in front of it. The turbo is OK, but the premier one is the Miller Mod with IO-360's. Now THAT is a machine. Michael |
#29
|
|||
|
|||
Whats the deal with counter-rotating props?
What's the deal with counter-rotating props? I mean they're props,
don't they all rotate? And what's up with this counter stuff. Who's counting, why is everyong always trying to count everything. (Sorry, couldn't help but hear Jerry Senfield in there somewhere). -Robert |
#30
|
|||
|
|||
Whats the deal with counter-rotating props?
One thing that hasn't been mentioned in this thread is the tremendous
amount of pure BS that is published and retold as the truth concerning both single and twin Comanches. Flight instructors check out new Comanche pilots without having a clue as to what they are doing. Mechanics work on Comanches and just make things worse. Two tales concerning the landing gear illustrate the point. Perhaps you recall the pictures of the Comanche landing gear up (in California, I think). The newsies called it a Cherokee, but it really was a Comanche. Anyway, a flight instructor was checking out a new Comanche pilot. The gear failed to extend, so they went to the emergency gear extension option. They removed the floor plate to access the release lever and proceeded to pump the gear down for the next hour, but could never get it to lock. Finally they landed gear up. The problem? The Comanche gear has no hydraulics to pump down! It is all electrical and mechanical. You simply push the lever all the way forward, and leave it there (like the manual gear in the early Mooneys)! Of course, neither pilot bothered to read the emergency extension procedure which was written on the back of the access plate they removed as the first step. The second tale concerns a Comanche pilot whose plane developed a hesitation in retraction after gear up was selected. So he went to his mechanic and described the symptoms. The mechanic thought a minute and then opined that it was probably a problem with the hydraulic power pac. There still aren't any hydraulics in the Comanche landing gear. The International Comanche Society and the Comanche Flyer Foundation have spent a bunch of money providing Comanche specific training for flight instructors. Use them. While it is very important for a single Comanche, it is vital for a twin. ICS can tell you who and where they are. Similarly, find an experienced Comanche mechanic. It will save you money in the long run. Hank Henry A. Spellman Comanche N5903P Dico wrote: Hello, We're looking into a twin and the Twin Comanche is on our list. I know that the later models have the counter rotating props -- although i don't know too much about what this means, other than its "better". We fly a mooney now and thus I don't worry about the prop -- as long as it keeps spinning. Is there a web site that gives a good explanation as to why I want CR props. There are hundreds of the earlier model Twin Comanches flying without the CR props --- so what does someone with 300 hours single engine time need to worry about? What actually goes wrong? And when it does, what happens? I hear "critical engine" but it means very little to me. I like to fly and try to be very careful when I do fly... but I don't follow too much aviation stuff other than how it affects me -- so I'm not exactly a "buff", hence the above questions which may seem obvious to many. Why are we looking at a Twin Comanche? Because its a twin, safer for IFR flight (perhaps this is only preceived), plus we live on the east coast on an island so we're flying over water quite a bit. Also this plane has decent speed and is an "economical" twin. We rarely fly with 4 people, so we don't need any more seats than 4. Any help or links to help would be appreciated. Thanks, Dico |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Counter rotating propellers | Raoul | Military Aviation | 24 | September 21st 04 05:59 AM |
Boeing Boondoggle | Larry Dighera | Military Aviation | 77 | September 15th 04 02:39 AM |
Warp drive or other ground adjustable props | Wallace Berry | Home Built | 0 | March 10th 04 04:02 PM |
Props and Wing Warping... was soaring vs. flaping | Wright1902Glider | Home Built | 0 | September 29th 03 03:40 PM |
Help needed - fs2004 zaps fs2002 props | Ian D | Simulators | 1 | September 11th 03 10:20 PM |