"Bob Kuykendall" wrote

Yup. They also don't seem to understand that someone who builds an
aircraft from a kit or from plans is under no obligation to register
that aircraft as having the same type as the kit prototype aircraft.
For example, many of the Schreder HP-series kit sailplanes have types
such as "Drew Two" and "RS-1" and "MR-3" instead of "HP-18" or "HP-11"
or "HP-14." So there are no doubt several CH-601XL aircraft to which
the NTSB's narrowly-worded letter A-09-30 does not apply.

Overall, I think that the NTSB, while perhaps meaning well, is being
too heavy-handed in asking the FAA to take this action. I think that
it would be far more constructive to work with Zenith and with
builders groups to make them aware of the issues and possible
mitigations. I think that it would be well within the FAA's purview to
firmly decline the NTSB's demands.
*************************
Jim wrote:
I see both sides of it, but think it is high time that the NTSB made a real
effort to get some changes made, and the top change is to make all of the
owners aware of the problems, as they see them.

As far as the flutter issue goes, the case was made that even planes that
had proper tension on controll cables have had cases of catestrophic
flutter. It should not be that hard to get a mass ballance engineered, such
as a "C" shaped ballance that penetrates the wing ahead of the hinge point,
and attaches to top and bottom of the aileron.
*****************************
If they ground every CH-601XL, what else could or might they have
taken action against? Adventurers with their horizontal stabilizer
attachment issues? BD-5As with their marginal takeoff characteristics
and flaky engines? Vari-Ezes (not Long-Ezes) with their somewhat
marginal wing carrythrough strength and attachment plate corrosion
issues? And that's just a few experimental airplanes, to say nothing
about gliders or rotorcraft. In all of these cases the carnage has
been kept to a dull roar by kit makers and builder communities who
(usually) worked together to raise awareness of the issues and to
mitigate them.
**********************
Jim wrote:
It could be said that the NTSB should have taken a more active stand in many
of the cases you mentioned, and many more might be alive. It would be a
fresh breeze to see action taken before more "blood rules" have to be
written.

If this is the case, it would be wrong to let more die, just because that is
the way it has been done in the past.
--
Jim in NC